《复合材料学报》优先在线发表论文。
摘 要：选用丁腈橡胶（NBR）/受阻酚AO-60（质量比100/40）作为阻尼相，环氧化天然橡胶（ENR）作为相容剂，制备了NBR/ AO-60-ENR-天然橡胶（NR）橡胶复合材料。研究发现，复合材料的微观结构呈“海岛结构”，当NR/NBR质量比为60/40和50/50时，体系中出现双连续相结构。复合材料呈现两个玻璃化转变温度，分别出现在-60℃附近和-10℃附近；随着NBR/AO-60相比例的增加，在-20~40℃温度范围内复合材料的有效阻尼温域从0℃拓宽到35.9℃，且损耗因子随应变增加有小幅提升。复合材料在低应变下呈现低应力，表现出高柔性，同时其在较高应变下存在应力突变点，表现出较高的拉伸强度、扯断伸长率。
关键词：橡胶；复合材料；阻尼性能；隔震支座；相容剂
Abstract: Natural rubber/nitrile butadiene rubber/hindered phenol AO-60/epoxidized natural rubber composites were prepared by using nitrile butadiene rubber (NBR)/hindered phenol AO-60 (100/40) as damping phase and epoxidized natural rubber (ENR) as compatibilizer. It is found that the microstructure of the composites is "sea-island structure" and the co-continuous morphology appears when the ratio of NR/NBR is 60/40 and 50/50. The composite exhibits two glass transition temperatures, which occur near -60 °C and around -10 °C. With the increase of NBR/AO-60, the effective damping of the composite in the temperature range of -20 -40 °C is widened from 0°C to 35.9°C, and the loss factor increases slightly with increasing strain. The composite exhibits low stress at low strain and exhibits high flexibility. At the same time, it has a stress crack point at higher strain, showing high tensile strength and elongation at break.
Keywords: rubber; composites; damping properties; isolation bearing; compatibilizer
作者：张志等，北京化工大学 北京市新型高分子材料制备与加工重点实验室, 北京
通讯作者：赵秀英，北京化工大学 北京市新型高分子材料制备与加工重点实验室, 北京
全文详见中国知网学术期刊优先数字出版。
来源：CSCM_OFFICE 中国复合材料学会
原文链接：https://mp.weixin.qq.com/s?__biz=MjM5MTA2NTk1Nw==&mid=2654408468&idx=4&sn=3f3f8e3de11cdc685fb82f917114a0aa&scene=0#wechat_redirect
版权声明：除非特别注明，本站所载内容来源于互联网、微信公众号等公开渠道，不代表本站观点，仅供参考、交流、公益传播之目的。转载的稿件版权归原作者或机构所有，如有侵权，请联系删除。
电话：（010）86409582
邮箱：kejie@scimall.org.cn
